DoorKing Series 6300 Instrukcja Właściciela

Owner’s Manual Series 2000 Inverter / Power Backup Systems P/N 2000-065 REV B, 2/01 Copyright 2001 DoorKing, Inc. All rights reserved. DoorKi

10 Batteries come in different sizes, types, amp hours, voltages and chemistries. Standard automobile batteries, called starting batteries, are des

11 The loads on the backup power system are seldom constant. Typically, large loads are operated for only short periods of time, such as when a gat

12

13 SECTION 2 – INVERTER OPERATION Shown below are the controls and indicator lights on the front panel of the inverter/charger. These control and p

14 2.1.3 Search Mode Watts This control is used for adjusting the sensitivity of the search mode circuit. Since the Model 2000 Power Backup System

15 2.1.6 Charger LED The battery charger in this inverter charges the batteries in three stages - BULK, ABSORPTION and FLOAT - to provide rapid and

16 2.1.9 Over Discharge Protection The over discharge protection control enables or disables the over discharge protection system (ODP) and allows

17 SECTION 3 – INSTALLATION WARNING!! DO NOT CONNECT BATTERIES TO THE BACKUP POWER SYSTEM UNTIL INSTALLATION AND WIRING OF THE SYSTEM IS COMPLETE

18 Prior to installing the backup power system, careful thought must be given as to where the unit will be installed. The system operates best when

19 3.1.1 In this layout, the Model 2000 is installed close to the vehicular gate system. Note that incoming AC power is routed into the Model 2000,

2

20 3.1.2 In this layout, the Model 2000 has been positioned close to the AC power distribution panel rather than being installed at the gate site. A

21 3.2.1 Conduits All wiring into and out of the backup power system enters the unit through the concrete mounting pad and is routed up behind the

22 3.2.3 MOUNTING THE UNIT These steps require two people to perform them. The Backup Power Unit is heavy and will require lifting. Attempting to l

23 SECTION 4 – WIRING WIRING OF THE MODEL 2000 INVERTER / POWER BACKUP SYSTEM SHOULD BE PERFORMED BY A QUALIFIED, LICENSED ELECTRICIAN. CONSULT LO

24 Be sure that the AC source power is disconnected or shut-off before attempting to connect the AC input wiring to the Backup Power System. Since

25 The Backup Power System provides six (6) output circuits, each of which is protected by a 20-amp circuit breaker. When using this system to prov

26 WARNING!! THE INVERTER IN THIS BACKUP POWER SYSTEM IS NOT REVERSE-POLARITY PROTECTED!! If the positive terminal of the battery is connected to t

27 SECTION 5 – CONTROLS AND ADJUSTMENTS The inverter / charger has its own control panel and indicator lights. These control and provide informatio

28 The Backup Power System uses a battery control board that monitors the charge condition of the battery bank. This control board will command eac

29 5.1.4 CONTROL BOARD WIRING Terminals P1, P2 and P3 are factory wired. The relay contacts on terminals P4, 1-14 are factory set for Normally Op

3 Use this manual with the following models only. Model 2000-080, 2000-081, 2000-082 with circuit board 2352-010. DoorKing, Inc. reserves the righ

30 5.1.5 OPERATION TEST BEFORE TESTING THE BACKUP POWER SYSTEM, BE SURE THAT ALL WIRING IS COMPLETE AND THAT THE BATTERIES ARE PROPERLY CONNECTED AN

31 SECTION 6 – MAINTENANCE AND TROUBLE SHOOTING MONTHLY MAINTENANCE At the minimum, check the level of the electrolyte in each battery cell once a

32 TROUBLE INDICATION POSSIBLE CAUSE POSSIBLE SOLUTION OVERLOAD – GREEN (LED): • Comes on after the inverter was running loads. • Comes on with

33 WIRE DIAGRAM

34 RMS, or Root Mean Square, is the measurement used for any time varying signal’s effective value: it is not an “Average” voltage and its mathemat

35 What is Inductance? When current passes through a conductor a magnetic field is set up around the conductor. As this magnetic field builds, it

36 If an electrical system has components grounded at different points in the earth (detail A), large voltage differences will exist between these

37 DoorKing Inc. (DoorKing) warrants the Model 2000 Inverter / Power Backup System to be free from defects in material and workmanship under normal

38 As a general policy, DoorKing, Inc. does not recommend the use of the Model 2000 Inverter / Power Backup System in life support applications whe

39

4

5 Section 1 - Preface Introduction...

6 Section 6 – Maintenance and Trouble Shooting Monthly Maintenance...

7 What is the Model 2000 Inverter? The DKS Series of Inverter / Power Backup systems are a unique style of battery backup devices. They are design

8 This manual contains important safety and operating instructions and specifications for all models of the DKS Inverter / Backup Power Systems. Th

9 • Someone should be within range of your voice to come to your aid when you work near batteries. • Have plenty of fresh water and soap nearby i